Transcription
2017 Audi Maintenance Schedule - All ModelsMY 2017 Maintenance Intervals - USAService IntervalsIf you are not sure when you should bring your Audi in for service or which services are to be performed on yourvehicle, ask your authorized Audi Service Advisor.Service intervals in miles10,000 miles1 or 1 year after delivery, whichever occurs firstMinor Maintenance Service20,000 miles2 or 1 year after previous service, whichever occurs firstStandard Maintenance Service with additional items30,000 miles or 1 year after previous service,whichever occurs firstMinor Maintenance Service40,000 miles or 1 year after previous service,whichever occurs firstStandard Maintenance Service with additional items50,000 miles or 1 year after previous service,whichever occurs firstMinor Maintenance Service60,000 miles or 1 year after previous service,whichever occurs firstStandard Maintenance Service with additional items70,000 miles or 1 year after previousservice, whichever occurs firstMinor Maintenance Service80,000 miles or 1 year after previous service,whichever occurs firstStandard Maintenance Service with additional items90,000 miles or 1 year after previous service,whichever occurs firstMinor Maintenance Service100,000 miles or 1 year after previous service, whichever occurs firstStandard Maintenance Service with additional items110,000 miles or 1 year after previous service, whichever occurs firstMinor Maintenance Service120,000 miles or 1 year after previous service, whichever occurs firstStandard Maintenance Service with additional items120,000 miles or 10 years, whichever occursfirstChange oil of front axle-drive (R8 only)130,000 miles or 1 year after previous service, whichever occurs firstMinor Maintenance Service with additional items130,000 milesTiming Belt Replacement (2.0L TDI and Audi A3 e-tron only)140,000 miles or 1 year after previous service, whichever occurs firstStandard Maintenance Service with additional items150,000 miles or 1 year after previous service, whichever occurs firstMinor Maintenance Service1) First minor maintenance service at 10,000 miles or 1 year after delivery, whichever occurs first. Minor maintenance services thereafter occur at intervals of 20,000 miles or 2 years after thelast minor maintenance service, whichever occurs first.2) First standard maintenance service at 20,000 miles or 2 years after delivery, whichever occurs first. Standard maintenance services thereafter occur at intervals of 20,000 miles or 2 yearsafter the last standard maintenance service, whichever occurs first.The intervals shown in this table are based on vehicles operating under normal conditions. In case of severe conditions, such as extremely low temperatures, excessive dust, etc., it is necessary for certain operations to be carriedout in between the given intervals. This applies particularly to engine oil changes and the cleaning or replacing ofthe air cleaner filter element.12/26/2016
Time-sensitive maintenance itemsService interval by time (and mileage whereapplicable)Maintenance itemEvery 2 years regardless of mileageReplace brake fluid (all vehicles)Every 2 years regardless of mileageCheck cloth top function and rollover protection with cloth topdown (Audi A5/S5 Cabriolet only)Every 2 years regardless of mileageCrash active headrest - Check function (Audi A8 only)Every 3 years regardless of mileageHaldex clutch - Replace oil (Audi A3, Q3, TT & TTS quattro only)Every 4 years regardless of mileageAdBlue Fluid - Replace only if AdBlue has not been filled withinthe last 4 years (All TDI models)Every 7 years regardless of mileageReplace battery connector on Connected Gateway (auto call incase of emergency) (Q7 & A4 only)Minor Maintenance ServiceFirst at 10,000 miles or 1 year after delivery, whichever occurs first. Thereafter, every 20,000 miles or twoyears, whichever occurs first. AdBlue fluid - Fill completely with fresh fluid and adapt learned values for AdBlue tank under guided fault finding after filling fluid (All TDI models) Brake system - Check for damage and leaks, thickness of pads, and brake fluid level Brake system - Check that the vent caps are mounted on calipers and check the condition of the brake hoses Cooling system for electrical components: Check coolant level according to description in ElsaPro (Audi A3e-tron and Q7 PHEV only) Engine oil / Oil filter - Change oil and replace filter Engine compartment - Check for leaks On-board diagnosis - Check (flex fuel vehicles only) Service reminder indicator display - Reset display Tires and spare wheel - Check for wear and damage. Check tire pressure. Reset Tire Pressure Monitoring System(TPMS) Water separator in fuel filter: Remove water (Audi A3, A4, and Q7 TDI models) Windshield washer and headlight washing system - Add fluid if necessary. Check adjustment and function Wiper blades - Check condition and replace if necessaryStandard Maintenance ServiceFirst at 20,000 miles or two years, whichever occurs first. Thereafter, every 20,000 miles or two years, whichever occurs first. 12 volt (small) side battery located in the trunk compartment on left side - check for clean terminals (no corrosion), properly mounted housing and no damage; replace if necessary (Audi Q5 hybrid only) Automatic transmission and final drive - Check for leaks Battery - Check for clean terminals (no corrosion), properly mounted housing and no damage; replace if necessary.Also, check the acid level of battery only if the level can be seen through the housing and fill if necessary (exceptAudi Q5 hybrid) Charging socket: Check for damage and make sure the socket is dry (Audi A3 e-tron and Q7 PHEV only) Crash active headrest - Check function (Audi A8 only) Cooling system - Check coolant level, add coolant if necessary, and check protection to spec-25 C Doors - Lubricate door hinges, straps, locks (all), hood hinges (R8 and TT only) and hood latch (R8 only) Hood Safety Catch – Lubricate (all) except TT, Q7, and A4 with integrated catch Drive shafts - Check boots Dust and pollen filter - Replace filter Exhaust system - Check for damage and leaks Front latch for Cabriolet roof - Lubricate (Audi A5, S5, and RS5 Cabriolets only) Front headlights- Check adjustment22/26/2016
Standard Maintenance Service (continued) Front lighting - Check function of parking lights, low beams, high beams, fog lights, blinkers & hazard lightsFront and rear axle - Check for excessive play. Check dust seals on ball joints and tie rod endsHorn - Check functionInstrument cluster- Check warning and indicator lightsInterior lights - Check all interior lights and glove box compartment illuminationManual transmission and final drive - Check for leaksOn-board tool kit- Check for completenessPanorama sunroof systems- Clean guide rails and lubricate with grease according to description in ElsaProPlenum Panel - Remove cover for plenum panel to check water drain and clean if necessary (all models except A3,Q3, R8, and TT)Rear lighting - Check function of brake lights (including third brake light), tail lights, back-up lights, rear fog lights,license plate lights, blinkers & hazard lights, and trunk lightRear spoiler hinges: Lubricate according to description in ElsaPro (A7, S7, RS7, RS5, R8, and TT only)Road test - Check engine performance, clutch, manual/auto transmission, braking (including hand and foot brake),steering, wheels, wheel bearings, drive shaft, horn, hybrid vehicles (electric drive for operational readiness)Rollover protection: Check function with soft top down (A3, A5, S5, and RS5 Cabriolets, and R8 Spyder only)Convertible top latch – lubricate (A5, S5, and RS5 Cabriolets only)Safety belts- Check clip for belt tongue and check function of all safety beltsSnow screen for air cleaner - Clean (Audi A4, S4, allroad, A5, A5 Cabriolet, S5, S5 Cabriolet, Audi Q5, SQ5, and Q5hybrid only)Sunroof systems- Check functionTire repair set - Check for completeness and renewal date (where applicable)Underbody (including front and rear closeout panels - Check for damage and leaksVisual check - Check the chassis for possible paint damage and corrosion, from the inside and outside with thedoors as well as hood and trunk lids openVisual check - Check that the wheel house liners, underbody panelling and lines are correctly mountedCharging socket – Check for cleanliness and damage (A3 and Q7 only)Check water drain in fuel filler door (R8 only)Check for stone chip protection on the rear axle/control arm. Check secure fit and for damage (A4 and Q7 only)Additional Maintenance ItemsPerform at 20,000 miles and thereafter every 20,000 miles. Fuel filter - Replace (All TDI models) Change the MTF oil for gear box (RS5 only) Air Cleaner - Clean the housing and replace filter element (RS5 and RS7 only)Perform first at 40,000 miles and thereafter every 40,000 miles. DSG/S tronic - Change ATF oil and replace transmission filter element for clutch hydraulicsDSG/S tronic - Change ATF oil for clutch hydraulics (Audi A3 e-tron and A6 front wheel drive only)Rear sport differential - Change ATF for clutch hydraulics and differential oil (RS5 and RS7 only)Air cleaner1) - Clean housing and replace filter element only on the following vehicles: (S3, A4 TDI, A5 TDI, A6TDI, A8 TDI, A8 3.0T, A8 4.0T, Q5 TDI, TTS)1) The S8 4.0L V8 TFSI engine is not included in this interval. It must be performed first at 60,000 miles and thereafter every 60,000 miles.Perform first at 40,000 miles or 4 years, whichever occurs first. Thereafter, every 40,000 miles or 4 years,whichever occurs first. Brake discs - Check thicknessPerform first at 40,000 miles or 6 years, whichever occurs first. Thereafter, every 40,000 miles or 6 years,whichever occurs first. Spark plugs2)- Replace (4.0L V8, A8L W12, and all 2.0L TFSI except Q3 only)2) Excludes 2.0L TFSI Flex Fuel engines]32/26/2016
Additional Maintenance Items (continued)Perform first at 30,000 miles or 6 years, whichever occurs first. Thereafter, every 30,000 miles or 6 years,whichever occurs first. Spark plugs - Replace (2.0L TFSI Flex Fuel engines onlyPerform first at 60,000 miles and thereafter every 60,000 miles. Air cleaner3) - Clean the housing and replace the filter element (A3, RS3, A4 (except TDI), S4, A5 (except TDI),S5, A6 (except TDI), S6, S8, Q3, Q7, and R8 only) Ribbed V-belt - Replace only the belt for the compressor drive (front belt) (all vehicles with the 3.0l V6 TFSI) Tiptronic gear box: Change ATF (Q5 Hybrid only)3) The air cleaner replacement at this interval includes the S8 4.0L V8 TFSI engine.Perform at 60,000 miles or 6 years, whichever occurs first. Thereafter, every 60,000 miles or 6 years, whicheveroccurs first. Spark plugs - Replace (A3 1.8T, Q3 2.0T, S4 3.0T, S5 3.0T, A8 3.0T, Q7 3.0T, and 5.2L V10 only)Perform at 80,000 miles and thereafter every 80,000 miles. Ribbed V-belt - Check condition and replace if necessary. Check tension of belt drive with a manual tensionerand retension if necessaryPerform after the first 120,000 miles or 120,000 miles after a Diesel Particulate Filter (DPF) replacement, andevery 20,000 miles thereafter. Diesel Particulate Filter (DPF) – Check ash loading according to manufacturer work procedure; replace4) if necessary (All TDI models)4) If DPF replacement is not necessary, perform check every 20,000 miles thereafter until replacement becomes necessary.Perform after the first 120,000 miles or 10 Years. Change front final drive 0D4 clutch and differential fluid (R8 only)Perform every 130,000 miles. Timing belt - Replace. Check condition of timing belt tensioning system, dampening pulleys, and idler pulleysand replace if necessary (2.0L TDI models and Audi A3 e-tron only)42/26/2016
Oil Capacity ChartEngine oilModelEngineA42.0L TFSI 252hp5.2L (5.5 qt)VW 502 00 or VW 504 00**Use synthetic oil SAE 0W-30, SAE 5W-30, orSAE 5W-40S43.0L TFSI 333hp6.8L (7.2 qt)VW 502 00 or VW 504 00**Use synthetic oil, SAE 0W-30, SAE 5W-30,or SAE 5W-40Q73.0L TFSI 333hp6.8L (7.2 qt)VW 502 00 or VW 504 00**Use synthetic oil, SAE 0W-30, SAE 5W-30,or SAE 5W-40Q73.0L TDI 258hp6.1L (6.4 qt)VW 507 00**Use synthetic oil SAE 0W-30 or SAE 5W-30R8 Coupe5.2L FSI 540hp8.3L (8.8 qt)VW 502 00 or VW 504 00**Use synthetic oil, SAE 0W-30, SAE 5W-30,or SAE 5W-40R8 Coupe5.2L FSI 610hp8.3L (8.8 qt)VW 502 00 or VW 504 00**Use synthetic oil, SAE 0W-30, SAE 5W-30,or SAE 5W-40Approx. qty.w/filter changeAudi Oil Spec** 2016 Audi of America, Inc.“All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual propertyrights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor maythese materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.”52/26/2016
Brake system - Check for damage and leaks, thickness of pads, and brake fluid level Brake system - Check that the vent caps are mounted on calipers and check the condition of the brake hoses Cooling system for electrical components: Check coolant level according to description in ElsaPro (Audi A3 e-tron and Q7 PHEV only) Engine oil / Oil filter - Change oil and replace filter Engine .
