Transcription
eerHutCKEEPING YOUR BOAT ON THE WATEROutboard EngineDVA CHARTSChrysler/ForceJohnson/EvinrudeOMC Sea DriveMercuryYamahaCDI Part # 961-0003Rev Q2/8/2012TECH SUPPORTCUSTOMER SERVICE1.866.423.48321.800.467.3371www. cdielectronics.com
CDI Electronics(DVA) PEAK READING VOLTAGE AND RESISTANCE CHARTSNOTICE: These charts were compiled using the CDI 511-9773NL Peak Adapterwith a shielded Digital Multimeter.(NOTE) The resistance readings are given for a room temperature of 68 F.Higher temperatures will cause a slightly higher resistance reading.DVA readings should always be taken with everything connected with theexception of the stop circuit.The CDI peak reading voltage adapter is specifically designed to work with shieldedDigital Multimeters. This adapter will simplify the testing of electronic ignition systems,stators, sensors and charging systems. The DVA readings will be approximately thesame as any other DVA meter and the specifications listed in the service manuals canbe followed without problems (Hopefully a little easier to you).The CDI piercing probe set (511-9770) and the pack load resister (511-9775) are highlyrecommended for use with this adapter.INSTRUCTIONS1. Plug the adapter into the shielded Digital Multimeter with the ( ) rib side pin in the(V, Ohms) jack and the other pin in the (COM) jack.2. Set the digital voltmeter to DC Volts (the purpose of the adapter is to convert andstore the voltage so that it can be read by a meter).3. Connect the probes to the component to be measured.(NOTE) The adapter will automatically compensate for polarity and all readingswill be peak voltage.See the following pages for readings of Chrysler, Force, Mercury, Johnson/Evinrude,OMC Sea Drive and Yamaha engines. Other ignitions can be tested using test resultsgiven by the manufacturer of the equipment or by comparing a known good system toa suspect one. Please forward any additional readings you would like to have includedin future printings.1CDI Part # 961-003Rev Q2/8/2013All rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics, Inc. is prohibited.
Chrysler/ForceDVA (Peak Reading) Voltage and Resistance 1116-9301*529301116-9301*7.519777.519791984All 19871991A, BW/CD &AlternatorW/CD &AlternatorW/CD &AlternatorW/CD &AlternatorW/CD &AlternatorW/CD &AlternatorW/CD &AlternatorAll 961999OE138600OE369299501988A, B, 01116-8301*StatorOhmsReadLow SpdHigh SpdBlue to BlueBlue to BlueBlue to BlueBlue to BlueBlue to YellowBlue to YellowBlue to YellowBlue to YellowBlue to YellowBlue to YellowBlue to YellowBlue to YellowBlue to Yellow (b)Blue toBlue/WhtRed toRed/WhtGreen/White toWhite/GreenBlue to Blue501988D5019891992All 19991977198019811983OE138600OE369299W/Magnapower II827509114-7509*1984All Models601985All Models6519771978W/Magnapower 78*Blue toEng GndRed toEng Gnd7019931995OE009500OE13859918495114-4953*Blue toEng GndRed toEng 1984W/CD &Alternator851983856XL8519841989All Models9019831984W/CD &Alternator901990All 91B&D332-7778114-7778*901991A, C & E658301116-8301*50555560Blk BlackBrn BrownAll 116-5301*Grn GreenOrg OrangeBlue to Yellow (b)Blue to Yellow (b)Blue toBlue/WhtRed toRed/WhtGreen/White toWhite/GreenT1 & T4 to Eng 075-9028-32*22002400*500-700400-600*Low SpdNot -400*Blue to YellowBlue to YellowBlue to Yellow (b)T1 & T4 to Eng GndNot White toWhite/GreenBlue to YellowBlue to Yellow (b)Blue toEng GndRed toEng GndBlue to Yellow (b)Pur PurpleWht ht/Blk to Brown, White &PurpleEng Gnd to Wht/Blk at CDMOhmsDVAPri48-520.5V N/A48-520.5V *125-140225-325*48-520.5V N/A48-520.5V N/A48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V N/A125-140225-325*80014004V 00800-1100800-1100800-1100800-1100Open1V N/A48-520.5V N/A48-520.5V N/A48-520.5V N/AWht/Blk to Brown, White &Purple80014004V 0.21.0800-1100Eng Gnd to Wht/Blk at CDMOpen1V N/A800-1100Org to GrnRed to Wht/Grn (a)Org to GrnRed to Wht/Grn (a)Org to GrnRed to Wht/Grn (a)Between TerminalsOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/Grn (a)Between TerminalsOpen0.5V 48-520.5V 48-520.5V 48-520.5V Open0.5V 00-1100200-2000Wht/Blk to Brown, White &Purple80014004V 0.21.0800-110075-9028-32*180400V25100VWht/Blk to Brown, White &Purple80014004V 0.21.0800-1100Eng Gnd to Wht/Blk, Wht/Yel,Blue/WhtOpen1V N/A900-110021002400*48-520.5V 48-520.5V 48-520.5V 48-520.5V 48-520.5V Wht/Blk to Brown, White &Purple80014004V 0.21.0800-1100Org to GrnRed to Wht/Grn (a)48-520.5V 5075-90220028-32*2400*680-850300-400*Yel Yellow180-400VReadOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/Grn (a)25100V680-850300-400*Blue to Yellow ue to Yellow (b)HighSpd75-9028-32*500-700400-600*Blue to YellowLowSpdIgnition 180-400V180-400V180400V25100V180-400VEng Gnd Engine GroundGnd Engine GroundOrg to GrnRed to Wht/GrnOrg to GrnRed to Wht/Grn (a)Org to GrnRed to Wht/Grn (a)Org to GrnRed to Wht/GrnOrg to GrnRed to Wht/Grn (a)N/A Not ApplicableCOMM 0-1100200-2000800-1100800-1100Pri PrimarySec Secondary* Indicates a part manufactured by CDI Electronics2CDI Part # 961-003Rev Q2/8/2013All rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics, Inc. is prohibited.
Chrysler/ForceDVA (Peak Reading) Voltage and Resistance hmsReadLow SpdHigh SpdLow SpdHighSpdLowSpdHighSpdReadOhmsDVAPriSecRed toEng k to Brown, White &Purple80014004V 0.21.0800-1100Eng Gnd to Wht/Blk, Wht/Yel,Blue/WhtOpen1V N/A900-110021002400*Open0.5V een/White 1T1 & T4 to Eng GndNot Applicable180-400V180-400VBlue toEng GndBD/BE/HA/HD/HEW/CD &AlternatorBD/BE/HD/HE475301116-5301*Blue to Yellow680-850300-400*474301-1T1 & T4 to Eng GndNot 0199490A, 91C658301116-8301*Blue to Yellow 9114-7509*Green/White toWhite/Green500-700400-600*120LDrive1990A, B, C658301116-8301*Blue to Yellow 772114-5772*12519811982W/CD &Alternator12519831989All *135197615019891991BD/BE/HD/HE89A, 90C,90D, 91A15019911992OE000001OE093699Blk BlackBrn Brown474301-1658301116-8301*332817323116-7323*Grn GreenOrg OrangeBlue to Blue/Wht (LS)Red to Red/Wht (HS)Blue to rg to GrnRed to Wht/GrnBetween Terminals0.21.00.21.00.21.00.21.0200-20000.5V Open0.5V Org to GrnRed to Wht/Grn (a)48-520.5V 180-400VEng Gnd to Wht/Blk, Wht/Yel,Blue/Wht, Brn/WhtOpen1V N/A900-110021002400*180-400VOrg to GrnRed to Wht/Grn (a)48-520.5V 0.21.0200-2000Brown to Wht/BlkPurple toWhite80014004V 0.21.0800-1100180-400VOrg to GrnRed to Wht/Grn48-520.5V 0.21.0800-1100Org to GrnRed to Wht/Grn (a)48-520.5V T1 & T4 to Eng GndNot Applicable180-400VBlue to Yellow (b)680-850300-400*Blue to Eng GndNot Appicable12V InverterYel YellowBetween Terminals48-52Blue to Yellow (b)Pur PurpleWht WhiteIgnition CoilOhmsTriggerDVABetween TerminalsOpen0.5V 180-400VOrg to GrnRed to Wht/Grn (a)48-520.5V 225-300VWht/Blk to Brn, Blk, Wht,Pur & Yel80014005V Eng Gnd Engine GroundGnd Engine GroundN/A Not ApplicableCOMM 00200-2000800-1100800-1100Pri PrimarySec Secondary* Indicates a part manufactured by CDI Electronicsa) Some units use a White/Orange trigger lead instead of a Green wire.b) Some Stator leads are Brown/Blue stripe instead of Blue and Brown/Yellow stripe instead of Yellow.Color Code Cross Reference3FunctionOldNewTriggerOrangeWhite/Orange StripeTriggerGreenWhite/Yellow StripeTriggerRedWhite/Red StripeTriggerWhite/Green StripeWhite/Green StripeStatorBlueBrown/Blue StripeStatorYellowBrown/Yellow StripePack Output to CoilOrangeOrange/BluePack Output to CoilRedBlue/RedIgnition CoilWhiteOrange/BlueStop CircuitWhiteBlack/YellowCDI Part # 961-003Rev Q2/8/2013All rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics, Inc. is prohibited.
Johnson/EvinrudeDVA (Peak Reading) Voltage and Resistance ChartHP4-60Year19781988ModelCD21989199319891993CDI W/SLOWPowerPack CD3Looper60-7519721978PowerPack 31977PowerPack alStartCD2 - USL19781987CD2/4Dual rge CoilOhmsBrown to Brown/YellowBrown to Brown/YellowBrown to Brown/YellowBrown to Brown/YellowBrown to Brown/YellowBrown to 0VN/APower CoilOhmsTriggerDVAReadOhmsDVAN/AN/AWhite/Black to Black/White15-500.6V N/AN/AN/AN/AN/A15-500.6V 450-550150-400VN/AN/AN/AWhite/Black to Black/White450-550150-400VN/AN/AN/AWhite/Black to Black/White15-500.6V 450-550150-400VOrange toOrange/Black450-55045-55*1122VWhite to Blue and Green15-50100400V10-2030-40*0.6V 400-600150-400VN/AN/AN/AWhite/Black to Black/WhiteBrown to Brown/Yellow720-880150-400VOrange toOrange/Black52-621122VN/AN/AN/ABrown to Brown/Yellow10101230150-400VOrange own to Brown/Yellow450-550150-400VOrange toOrange/Black450-55045-55*1122VBrown to 1113-3072*113-3101*White to Blue/Purple/GreenWhite to Black/WhiteBlack/White to White/BlacksBrown to Brown/Yellow450-550150-400VN/AN/AN/AWhite to Blue/Purple/Green38-420.6V Brown to Brown/Yellow450-550150-400VOrange toOrange/Black450-55045-55*1122VWhite to Blue/Purple/Green38-42100400VBrown to Brown/Yellow450-550150-400VN/AN/AN/AWhite to Blue/Purple/Green38-420.6V Brown to Brown/Yellow450-550150-400VOrange toOrange/Black450-55045-55*1122VWhite to Blue/Purple/Green38-42100400VBrown to Brown/Yellow450-550150-400VN/AN/AN/AWhite to Blue/Purple/Green/Pink11-45100400VBrown to Brown/Yellow400-600150-400VN/AN/AN/A#1 to #3 and#2 to #410-2030-40*0.6V N/AN/AN/AWhite to Blue and GreenWhite/Black to Blue/Whiteand Green/White11-450.6V Brown to Brown/Yellow9 AMP450-5509 AMP150-400VBrown to Brown/Yellow35 AMP950110035 AMP150-400VBrown to Brown/Yellow450-550150-400VN/AN/AN/AWhite to Blue/Purple/Green/Pink11-450.6V 586292113-6292*Brown to Brown/Yellow (orBrown/White)9001200150-400VOrange toOrange/Black50-601122VOrange/Red to Eng GndBlack/Orange to Eng GndN/A10.5-12VDC8-10VDCBrown to Brown/YellowBrown to Brown/Yellow9 AMP450-55035 AMP95011009 AMP150-400V35 AMP150-400V0.6V Orange toOrange/Black93-10045-55*1122VWhite to Blue/Purple/Green/PinkWhite to Blue/White,Purple/White, Green/White and Pink/White35-55584041113-4041*1201301.5V 1251996584032Brown to Brown/White to -4032*YellowGreen/PinkManual St.Blk BlackGrn GreenPur PurpleYel YellowEng Gnd Engine GroundN/A Not ApplicablePri PrimaryBrn BrownOrg OrangeWht WhiteGnd Engine GroundCOMM CommercialSec Secondary* Indicates a part manufactured by CDI ElectronicsNOTE: Ignition Co
1987-1991 All Models 529301 116-9301* Blue to Yellow (b) 680-850 300-400* 180-400V Org to Grn Red to Wht/Grn (a) 48-52 0.5V N/A 125-140 225-325* 40 1992-1995 OE000001-OE138599 18495 114-4952* Blue to Blue/Wht Red to Red/Wht 3250-3650 2200-2400* 75-90 28-32* 180-400V 25-100V Wht/Blk to Brown, White & Purple 800-1400 4V 0.2-1.0 800-1100 40 1996 .
