Transcription
IGNITION AND ELECTRONICS .06
MOPAR PERFORMANCE TERMS AND CONDITIONSNOTICEFederal and many state laws prohibit the removal, modification or rendering inoperativeof any part or element of design affecting emissions or safety on motor vehicles used fortransporting persons or property on a public street or highway. Violation may result in afine of up to 32,500 per vehicle. Mechanical and/or electronic performance parts listedin this catalog with a “1” cannot be used on vehicles used on public streets or highways.These parts may be used only on vehicles used solely in sanctioned off-highway events. No other applicationsare intended or implied. Those parts that have been granted an exemption by the California Air Resources Board(CARB) or meet the EPA requirements of memorandum 1A are legal for highway use in California, New York, andMassachusetts and are noted as such.NO PARTS WARRANTY – “AS IS”Mopar Performance parts beginning with a “P” prefix are sold “as is” unless otherwise noted. This means thatparts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of merchantability, are excluded. (An implied warranty of merchantability means that the part is reasonably fit for thegeneral purpose for which it was sold). The entire risk as to quality and performance of such parts is with thebuyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributoror retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep , Dodge and Ram vehicleand parts warranties are voided if the vehicle or parts are used for competition. The addition of performance partsdoes not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied onthe vehicle from the factory) are not covered by the vehicle’s warranty, and any failure that they may cause is alsonot covered by the vehicle’s warranty.MOPAR PERFORMANCE CRATE ENGINE 90-DAY LIMITED WARRANTYMopar Performance Crate Engine Assemblies not used in competition are warranted for “parts only,” AS DELIVERED against defects in materials or workmanship for 90 days from the date of purchase. The following parts, ifdefective, will be replaced on an exchange basis for 90 days: engine blocks and all internal parts; cylinder headassemblies; intake manifold; core plugs; valve covers; oil pan; timing gear; water pump; gaskets and seals. Seeyour dealer for a copy of the limited warranty, which contains additional terms and limitations.MOPAR PARTS 12-MONTH LIMITED WARRANTYExcept parts as listed above, certain parts from Mopar Performance sold over the counter or wholesaled arewarranted against defects in workmanship or materials for 12 months/unlimited miles for parts (exchange) only.These parts are identified in this catalog as having a specific part number structure. Part numbers starting with“P” are not covered under the 12-month warranty. Other parts listed in this catalog without a “P” prefix part number are covered under the 12-Month Limited Warranty described here. See your dealer for a copy of the limitedwarranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep , Dodgeand Ram vehicle by an authorized Chrysler, Jeep , Dodge and Ram dealer are warranted for 12 months/unlimitedmiles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional termsand limitations.
EMISSIONS STATEMENTFederal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles,whichever comes first. Federal and many state laws also prohibit the removal, modification or rendering inoperative any part that affects emissions or safety on motor vehicles used on public streets or highways. ManyMopar Performance parts are designated for track use or off-road use only. Installation of certain componentsmay bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends thatvehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customersare responsible for complying with applicable state and local environmental regulations. Additionally, certainperformance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle,and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissionstest, including any test required to maintain or renew your vehicle’s registration, or if your vehicle is subjectto an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissionsperformance warranty, and you may be required to remove those parts at your own expense in order to obtainrepairs necessary to pass the I/M test or to perform the recall.NOTE — CALIFORNIA ONLYThe emissions laws and regulations of the state of California apply to all non-racing vehicles operated inCalifornia. Consequently, those parts marked in this catalog with a “1” and appropriately marked on theirpackaging may legally be used in California only on a racing vehicle that will never be operated on publicroads.PARTS ORDERING AND INQUIRIESThe parts in this catalog may be ordered from authorized Chrysler, Jeep , Dodge and Ram dealerships or thespeed shops carrying the Mopar Performance line of products. When a part ordered has been superseded,the replacing part will be shipped automatically. The price of the replacing part may differ from the orderedpart. All products, illustrations and specifications are based upon current information at the time of publicationapproval. Although descriptions are believed correct, complete accuracy cannot be guaranteed. ChryslerGroup LLC reserves the right to make changes at any time, without notice or obligation, to the informationcontained in this printed document, including and without limitation to prices, specifications, equipment,colors, materials, and to change or discontinue products.Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.
TABLE OF CONTENTSENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 10Hemi , Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .101011121212121314141515171719Hemi , Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Installation Components . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22242525262627272829303234353739Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .424242434344505153P. 4Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54565760Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6466696970717478828587909395RESTORATION . . . . . . . . . . . . . . . . . . . . . . 100Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . .Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100101102102104106Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . .108Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . .Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . .Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108109110111112113113114114Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . .116Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .Automatic Transmission Components . . . . . . . . . . . . . . . . .Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . .Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . .116116116118119
TABLE OF CONTENTSTorque Converters and Hardware . . . . . . . . . . . . . . . . . . . .119Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . .122Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . .Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . .Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .122123123125Drivetrain and Rear Axle Components . . . . . . . . . . . . . .128Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . .Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .128129130Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . .132Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Frame Components . . . . . . . . . . . . . . . . . . . . . . .
or retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep , Dodge and Ram vehicle and parts warranties are voided if the vehicle or parts are used for competition. The addition of performance parts does not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied on the vehicle from the factory) are not covered by .
